Developing an Ethanol Utilization Pathway based NADH Regeneration System in Escherichia coli

Research Article | DOI: https://doi.org/10.31579/2766-2314/059

Developing an Ethanol Utilization Pathway based NADH Regeneration System in Escherichia coli

  • Wenfa Ng 1

Department of Chemical and Biomolecular Engineering, National University of Singapore.

*Corresponding Author: Wenfa Ng, Department of Chemical and Biomolecular Engineering, National University of Singapore.

Citation: Wenfa Ng (2021) Developing an Ethanol Utilization Pathway based NADH Regeneration System in Escherichia coli. J, Biotechnology and Bioprocessing 2(9); DOI: 10.31579/2766-2314/059

Copyright: © 2021,Wenfa Ng, This is an open access article distributed under the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Received: 29 September 2021 | Accepted: 12 October 2021 | Published: 28 October 2021

Keywords: cofactor regeneration, ethanol utilization, glucose dehydrogenase, biotransformation, whole-cell biocatalysis

Abstract

Interests remain in searching for cofactor regeneration system with higher efficiency at lower substrate cost. Glucose dehydrogenase (GDH) system has been dominant in NADH regeneration, but it only has a theoretical yield of one NADH per glucose molecule. This work sought to explore the utility of a two-step ethanol utilization pathway (EUP) in pathway-based NADH regeneration. The pathway runs from ethanol to acetaldehyde and to acetyl-CoA with each step generating one NADH, that together results in a higher theoretical yield of two NADH per ethanol molecule. In this project, anaerobic biotransformation of ketone (acetophenone or butanone) to alcohol by cpsADH from Candida parapsilosis was used as readout for evaluating relative efficacy and operating modes for EUP cofactor regeneration in Escherichia coli BL21 (DE3). Experiment tests validated that EUP was more efficient than GDH in NADH regeneration. Further, growing cell delivered higher biotransformation efficiency compared to resting cell due to the driving force generated by cell growth. Finally, preculture or cultivation in M9 + 10 g/L ethanol medium delivered higher biotransformation efficiency compared to LB medium. Overall, EUP could help regenerate NADH in support of a biocatalytic reaction, and is more efficient in cofactor regeneration than GDH.

Introduction

Cofactor dependent oxidoreductases play a hugely important role in biocatalysis and biotransformation. Specifically, these enzymes are the pillars on which we could perform difficult organic chemistry kinetic resolution or biotransformation in whole cells under mild conditions compared to harsh conditions used in synthetic organic chemistry [1, 2].  Dependence on cofactors naturally meant that provision of expensive cofactors on a stoichiometric basis is necessary for maintaining high product yield. The alternative solution is that of using cofactor regeneration systems to provide needed cofactors for a biotransformation [3, 4].  Principally, a cofactor regeneration system utilizes an enzyme to convert a sacrificial substrate to a second product that in the process also help regenerate the cofactor needed by the main biotransformation reaction. 

As construed, the enzymatic cofactor regeneration system works in tandem with the main biotransformation reaction to help convert the main biotransformation substrate into the target product. Such a system would only work and remain coupled if the rates of the cofactor regeneration reaction is comparable to that of the main biotransformation reaction [5]. But, the main benefit of a cofactor regeneration system is in shifting the cost burden from provision of expensive cofactor to that of the sacrificial substrate, which could be low-cost [6]. Another less often noted concern in cofactor regeneration is the generation of a byproduct that could complicate the downstream separation of the main biotransformation product [6]. Thus, work in the biocatalysis field has been on the search for low-cost sacrificial substrate/enzyme system that could be usefully tapped for cofactor regeneration without posing separation concerns for the main biotransformation product [7, 8].

In the area of NADH regeneration, glucose dehydrogenase (GDH) enzyme remains the most popular and dominant [9-12]. Other NADH regeneration systems include formate dehydrogenase [13-15], and NADH oxidase [16-18].  To be effective and useful, a cofactor regeneration system should deliver high yield of cofactor per molecule of substrate, and less often noted, be of relatively fast kinetics. For example, glucose dehydrogenase available in Bacillus species converts glucose to gluconolactone with the generation of one NADH [19]. This meant a cofactor yield of one NADH per glucose molecule. Formate dehydrogenase, on the other hand, converts formate to carbon dioxide with the generation of one NADH [20]. But, the system suffers from potential problem with the acidification of the medium due to carbon dioxide dissolution [21]. Finally, NADH oxidase offers the most tantalizing prospects of a cofactor regeneration system delivering a benign product. Specifically, NADH oxidase uses molecular oxygen to convert NAD+ to NADH with the generation of either H2O2 or water [22]. But, dependence on molecular oxygen meant that NADH oxidase could only operate under aerobic conditions, which restricts its application space in biocatalysis.

Work described in this manuscript sought to demonstrate the NADH cofactor regeneration potential of a two-gene ethanol utilization pathway (EUP) that sequentially converts ethanol to acetaldehyde and on to the growth promoting metabolite, acetyl-CoA. The first step of the pathway is mediated by adh2 from Saccharomyces cerevisiae with the generation of one NADH [23].  This is followed by the second step of the pathway mediated by ada from Dickeya zeae that generates another NADH [23].  Hence, from the theoretical perspective in this project, EUP generates two NADH per ethanol molecule, and is more efficient in cofactor regeneration than the glucose dehydrogenase system. More importantly, the two-gene pathway ends in acetyl-CoA, which can be connected to central carbon metabolism, thereby, enabling distribution of ethanol flux to growth processes in growing cell biotransformation, that theoretically, could provide a greater driving force for NADH regeneration. In addition, acetyl-CoA remains in the cell and would not complicate downstream separation of biotransformation product. Finally, lack of oxygen dependence meant that the EUP could operate under both aerobic and anaerobic conditions, which expands the operating envelope of the cofactor regeneration system. This project sought to convert ethanol to acetyl-CoA with NADH regeneration that could be usefully tapped for biocatalysis. 

In theory, cofactor regeneration could be implemented in vitro or in vivo [24].  The latter is more attractive as whole-cell biocatalysis delivers better performance after issues such as enzyme cost and stability are taken into account [25]. This project chose Escherichia coli to implement a whole cell biocatalytic system. The coupling biotransformation reaction is chosen as the ketone to alcohol biotransformation mediated by a proven NADH-dependent alcohol dehydrogenase (cpsADH) from Candida parapsilosis [26]. Two substrates, acetophenone (hydrophobic) and butanone (hydrophilic) are chosen in this project to test the utility of EUP in regenerating NADH under circumstances of a two-phase or single aqueous phase biotransformation system common in biocatalysis.

Experimental results collected in this project revealed that E. coli harbouring the EUP pathway could grow on ethanol, which meant that the two-step EUP pathway is functional. More importantly, in biotransformation assays converting butanone to 2-butanol, product yield was enhanced with use of EUP relative to glucose/GDH system. This validated theoretical predictions that the EUP pathway is more efficient in regenerating NADH compared to glucose/GDH system. Furthermore, growing cells were shown to enable higher biotransformation efficiency compared to resting cells presumably due to the driving force generated by cell growth that push ethanol flux to acetyl-CoA. Finally, gene expression pattern resultant from cultivation in different growth media either prior to or during biotransformation also impact on biotransformation efficiency. In this case, M9 medium supplemented with 10 g/L ethanol was shown to enable higher biotransformation efficiency compared to LB medium in both resting cell and growing cell biotransformation. 

The overall picture that emanates from the experimental results collected in this project point to ethanol utilization as a viable platform for regenerating NADH in whole cell biocatalysis converting either acetophenone to 1-phenylethanol or butanone to 2-butanol in E. coli. Given that it is a plasmid-based platform, the two-gene EUP pathway could be readily transplanted to other species for enabling NADH regeneration in support of a NADH requiring biotransformation reaction. Although EUP is more efficient than the state-of-the-art GDH system in regenerating NADH, higher cost of ethanol may still tilt the balance in favour of GDH system. The aim of this article is to describe the experiment work that validated the utility of EUP as a cofactor regeneration system for E. coli in biocatalysis applications, and some of its operational dependencies and characteristics.

Materials and Methods

2.1. Chemicals and medium composition

LB medium was purchased from Difco and used as is. Composition of LB medium was (g/L): Tryptone, 10.0; NaCl, 10.0; Yeast extract, 5.0. Composition of potassium phosphate buffer was (g/L): K2HPO4, 12.54; KH2PO4, 2.31. Composition of modified M9 medium was (g/L); K2HPO4, 6.8; KH2PO4, 3.0; NH4Cl, 1.0; NaCl; 2.0; Yeast extract, 1.0; Ethanol, 10.0. Composition of high cell density medium was (g/L): K2HPO4, 12.54; KH2PO4, 2.31; D-Glucose, 4.0; NH4Cl, 1.0; NaCl; 5.0; Yeast extract, 12.0; MgSO4, 0.24. Antibiotics used were ampicillin (100 µg/mL) and spectinomycin (50 µg/mL). Acetophenone, 1-Phenylethanol, glucose, butanone, 2-butanol, n-hexadecane and ethyl acetate were of analytical reagent grade (99%) and purchased from Sigma Aldrich.

2.2. Plasmid construction

Ethanol utilization pathway comprises two genes: adh2 and ada were placed under the control of an autoinducible promoter, PthrC3 and inserted into a plasmid backbone with ampicillin as antibiotic resistance marker. Adh2 was cloned from Saccharomyces cerevisiae and ada was cloned from Dickeya zeae by my labmate, Ms Liang Hong, from whom I inherited the initial pathway. pMB1 serves as the origin of replication in this plasmid. On the other hand, cpsADH alcohol dehydrogenase enzyme was cloned from Candida parapsilosis and placed under the control of an autoinducible promoter, PthrC3, and inserted into a plasmid backbone with spectinomycin antibiotic resistance marker. I inherited this plasmid from Mr. Liu Hongyuan from the lab. The replication origin of this plasmid is pA15. Given their differing antibiotic resistance marker and replication origin, both plasmids could be stably maintained in E. coli BL21 (DE3). Both plasmids were transformed into Escherichia coli BL21 (DE3) using standard heat shock transformation method.

2.3. General procedure for cloning of genes from bacterial species

Glucose dehydrogenase (gdh, Bacillus subtilis), aldehyde dehydrogenase (aldA, E. coli) and alcohol/aldehyde dehydrogenase (adhE, E. coli) were cloned from their respective bacterial species. Using appropriate primers, the respective genes were cloned through colony PCR in the thermocycler (Biorad, T-100). Specifically, 1 µL of a 16 hour bacterial culture in LB Miller medium was used as template for PCR amplification. PCR cycling conditions were: 98 oC for 5 mins, followed by 34 cycles of (98 oC for 8 sec, 55 oC for 15 sec, and 72 oC for 120 sec), with final extension of 72 oC for 5 mins. The PCR product was clean-up through gel electrophoresis (130V for 30 mins, Biorad power pack) followed by gel purification using Thermo Fisher Scientific gel purification kit (GeneJet Gel Extraction Kit, Cat No: #0692). The resulting gene fragment was ligated with the plasmid backbone using a ligase-free ligation method developed in the lab that includes incubation with 10 mM MgCl2 in a thermocycling step in a PCR thermocycler (Biorad, T-100). The cycling programme was as follows: 80 oC for 1 min, 68 oC for 10 mins, and infinite hold at 4 oC. DNA assembly method used was developed in the lab and is known as the GT standard [27]. 

After plasmid ligation, colony PCR with appropriate primers were used to confirm ligation of gene fragment with plasmid backbone. Amplified gene fragment was extracted and purified with a gel purification kit (GeneJet Gel Extraction Kit, Cat No: #0692). Sequence of the gene fragment was verified by Sanger sequencing (BioBasic Singapore). Primers used for the experiments are as listed in Supplementary Table 1 below.

Supplementary Table 1: Primers used in the ethanol cofactor regeneration project

2.4. Cell cultivation

E. coli was inoculated in 10 mL LB medium with 100 µg/mL ampicillin and 50 µg/mL spectinomycin in 125 mL shake flask. Incubation conditions were 37 oC and 225 rpm for all cultivations. The incubator used was N-Biotek NB-205 Incubator-shaker. After 5 hours of cultivation, 0.25 mL of seed culture served as inoculum for 25 mL of LB medium with antibiotics in a 125 mL shake flask and the experiment cultures were cultivated for 20 hours. Optical density of the culture broth was measured at 600 nm with a UV-Visible spectrophotometer (Ambersham Biosciences). Appropriate dilution with deionized water was performed for samples with absorbance that exceed 1. Cells were harvested for biotransformation by centrifugation at 3300g for 5 minutes. Subsequently, cells were resuspended with 89 mM potassium phosphate buffer for a washing step, which included centrifugation at 3300g for 5 minutes. Cells were finally resuspended in 89 mM potassium phosphate buffer with a factor of 2 concentration in optical density for resting cell biotransformation. In growing cells biotransformation, cells were not washed with potassium phosphate buffer but were transferred into either LB Miller medium or M9 ethanol medium with a factor of 0.1 in optical density.

2.5. Acetophenone biotransformation

Given the poor solubility of acetophenone and 1-Phenylethanol in water, a two-phase system comprising n-hexadecane and potassium phosphate buffer was used in biotransformation. Specifically, either 5 or 20 g/L acetophenone was dissolved in 0.5 mL of n-hexadecane, while 0.5 mL of potassium phosphate buffer contained E. coli cells and 10 g/L ethanol. The reaction mixture was contained in 2.0 mL HPLC vial and incubated anaerobically at 37 oC and 225 rpm for 20 hours. Duplicate experiments were carried out. Cells were precultivated in LB medium for resting cells experiments. 

At suitable time-points, HPLC vials were removed from the incubator. The contents were transferred to a 1.5 mL microcentrifuge tube and centrifuged at 20000g for 2 minutes. The upper organic phase containing the substrate and product was aliquoted and diluted with ethyl acetate prior to gas chromatography-mass spectrometry (GC-MS) analysis for detecting acetophenone and 1-Phenylethanol. Following that, the organic phase was carefully removed by pipetting; thereby, leaving behind an aqueous phase where 200 µL was aliquoted, filtered through a 0.22 µm nylon filter prior to high performance liquid chromatography (HPLC) analysis for detecting ethanol and acetate. 

The performance measure selected for this segment of the work is yield per unit optical density, and is as defined below:

Equation 1

2.6. Butanone biotransformation

Since butanone and 2-butanol are highly water soluble, only a single-phase biotransformation system is required. Specifically, 10 g/L of butanone is added to either potassium phosphate buffer (resting cells) or growth medium (growing cells) together with 10 g/L of glucose or ethanol for biotransformation. Concentrations of butanone and ethanol were titrated in experiments aimed at understanding the effect of substrate toxicity effect or whether provision of higher ethanol concentration would drive higher biotransformation efficiency, respectively. The reaction mixture was contained in 2.0 mL HPLC vial and incubated anaerobically at 37 oC and 225 rpm for 44 hours. Triplicate experiments were carried out.

At suitable time-points, HPLC vials were removed from the incubator. The contents were transferred to a 1.5 mL micro centrifuge tube and centrifuged at 20000g for 2 minutes. 200 µL of the supernatant was aliquoted, filtered through a 0.22 µm nylon filter prior to high performance liquid chromatography (HPLC) analysis for detecting, butanone, butanol, ethanol or glucose and acetate. 

The performance measure selected for this segment of the work is yield per unit optical density, and is as defined below:

Equation 2

2.7. Gas chromatography mass spectrometry and high performance liquid chromatography analysis

Gas chromatography mass spectrometry was used in analysing the concentration of acetophenone and 1-Phenylethanol in Agilent 7890 GC and Agilent 5977B MSD. Injection volume used was 1 µL and the oven temperature profile used was 50 oC for 1 min, ramp from 50 to 180 oC at 10 oC/min, followed by another ramp from 180 to 280 oC at 50 oC/min and a hold at 280 oC for 3 minutes. MS detector was turned off at 13 minutes to protect the mass spectrometry detector.

High performance liquid chromatography was conducted with an Agilent 1260 series instrument equipped with a Bio-rad Aminex HPX-87H column. 5 µL of sample was injected into the column and eluted with 5 mM sulphuric acid at 0.7 mL/min. Isocratic elution was used and the column was maintained at 50 oC. Analytes were detected by a refractive index detector.

2.8. Data analysis and statistical methods

Experiments were conducted in triplicate, and the average of the three measurements is reported. Experimental error is quantified via the average deviation approach, which measures the average deviation of each measurement from the average value.[28]

Results

Result

Figure 1. Conceptual basis of ethanol utilization pathway (EUP) and whole cell biocatalysis. A) Ethanol utilization pathway delivers higher NADH regeneration capability compared to glucose dehydrogenase system, B) Integration of EUP with cpsADH in an Escherichia coli BL21 (DE3) whole cell biocatalytic system.

At the theoretical level, the two gene ethanol utilization pathway (EUP) delivers one NADH per step of the pathway that culminates in two NADH generated per ethanol molecule. This is a 100% improvement over the competing glucose dehydrogenase (GDH) system which regenerates one NADH per glucose molecule (figure 1a). Hence, theoretically, the EUP pathway is more efficient than GDH in regenerating NADH. 

To be effective, the EUP pathway must be integrated with cpsADH in a whole cell biocatalytic system with E. coli BL21 (DE3) as microbial chassis. Specifically, the two gene EUP pathway is encoded on a plasmid with pthrC3 auto inducible promoter, while cpsADH enzyme is encoded on another plasmid with pthrC3 auto inducible promoter. The whole cell biocatalytic system works by up taking ethanol and converting it into acetyl-CoA with the generation of two NADH per ethanol molecule. At the same time, butanone or acetophenone would be taken up by the cell and converted by the NADH dependent cpsADH into alcohol which is secreted out of the cell (figure 1b). Amount of 2-butanol or 1-phenylethanol produced would be taken as yardstick to assess the biotransformation efficiency of the cofactor regeneration system.

EUP ends with acetyl-CoA, which is a growth promoting metabolite. Thus, if the pathway is functional, provision of ethanol in M9 medium should engender growth. Experimental results in M9 + 10 g/L ethanol medium reveals that the EUP pathway was functional and could support growth of E. coli ethcps2 under aerobic conditions. Specifically, rapid growth of E. coli ethcps2 during exponential phase coincided with ethanol utilization (Supplementary figure S1a). Similarly, E. coli ethcps2 could attain appreciable growth in M9 ethanol medium under anaerobic conditions at 37 oC and 225 rpm. This is consistent with theoretical predictions in this study that the EUP pathway genes would be expressed under anaerobic conditions and that the enzymes are not dependent on oxygen for function. More significantly, E. coli ethcps2 could attain comparable growth in M9 medium supplemented with either 10 g/L glucose or ethanol (Supplementary figure S1b).

Figure 2. EUP could support acetophenone biotransformation in E. coli in a two phase system. A) Autoinducible pthrC3 promoter delivered higher biotransformation efficiency compared to T7 promoter in E. coli microbial chassis at 37 oC and 225 rpm in resting cells anaerobic biotransformation, B) Formation of 1-Phenylethanol product was rapid in the first few hours of the biotransformation, but tapered towards the latter stage of the process, C) Yield per unit OD improved with increase in acetophenone substrate concentration, thereby, indicating that the n-hexadecane organic phase could store and ameliorate potential toxicity effect from elevated acetophenone concentration, D) Higher incubation temperature favoured the formation of more 1-Phenylethanol product and greater biotransformation efficiency.

The first part of the project concerns the integration of the EUP cofactor regeneration system with cpsADH enzyme as a whole-cell biocatalytic system suited for the biocatalytic conversion of ketone to alcohol. Acetophenone, a hydrophobic substrate, would be the first substrate to be tested. To be useful, a promoter needs to drive the transcription and expression of EUP genes. In this project, a synthetic T7 promoter commonly used in biotechnology and an auto inducible pthrC3 promoter from E. coli are evaluated. As this was a resting cell experiment, E. coli cells harbouring EUP plasmid with T7 promoter were induced with 0.1 mM IPTG 3 hrs into cell cultivation. Experimental results revealed that biotransformation efficiency of acetophenone to 1-phenylethanol biotransformation was higher when EUP genes were under the control of pthrC3 compared to T7 promoter (figure 2a). This came about presumably due to the higher expression of genes under the control of auto inducible pthrC3 promoter compared to T7 promoter.

Kinetics of biotransformation is a hugely important parameter that governs the industrial feasibility of a given reaction. Experimental data in figure 2b showed that the acetophenone to 1-phenylethanol biotransformation was quite rapid in the first few hours, but reaction slowed towards latter part of the reaction. This points to possible equilibrium control of the biotransformation reaction as cpsADH is a reversible enzyme able to catalyze both directions of the biotransformation reaction. Next, acetophenone substrate loading experiments were carried out to determine the extent in which the approach would help push the reaction forward towards product formation. Data revealed that higher biotransformation efficiency was obtained with higher acetophenone loading moving from 1 g/L to 20 g/L acetophenone (figure 2c). Importantly, no substrate toxicity effect was observed due to the n-hexadecane phase serving as a reservoir for acetophenone, which only allows small amount (solubility limit) of the substrate to come into contact with cells. Finally, efforts to reduce the process temperature to either 30 or 25 oC showed that this was not possible. In particular, product yield and biotransformation efficiency improved in a monolithic fashion with incubation temperature moving from 25 to 37 oC (figure 2d). 

Figure 3. EUP enabled butanone biotransformation in single phase system in resting cells precultivated in M9 + 10 g/L ethanol medium at 37 oC and 225 rpm. A) EUP pathway delivered higher biotransformation efficiency compared to endogenous glucose and ethanol metabolization systems, B) Butanone consumption was highest in cells fed with ethanol, thereby, indicating a correlation between NADH regeneration and butanone utilization, C) Ethanol utilization was poor over the two day incubation period, which points to room for engineering higher ethanol utilization, D) Acetate formation was highest in cells fed with ethanol, which indicates that acetyl-CoA conversion to acetate is a major route for channelling ethanol pathway flux in resting cells.

Work subsequently moved to determine the efficacy in which the EUP pathway could support a ketone to alcohol biotransformation reaction in single aqueous phase. Butanone is the substrate chosen due to its hydrophilic nature, and where the corresponding product, 2-butanol is a useful biofuel. Resting cells equipped with both EUP and cpsADH (i.e., E. coli ethcps2) were cultivated in M9 + 10 g/L ethanol medium. E. coli cells without EUP but with cpsADH (i.e., E. coli cps2) was used to examine the ability of the endogenous ethanol and glucose utilization pathways in regenerating NADH. In all experiments, glucose was the reference substrate to serve as positive control as provide comparison for the relative utility of EUP and endogenous ethanol utilization system in regenerating NADH. 

Experiment results revealed that EUP could support butanone biotransformation to 2-butanol through regeneration of NADH. For comparison, the yield per unit OD of cells with EUP was 2 times that of cells with endogenous ethanol utilization system (figure 3a). More importantly, endogenous ethanol and glucose utilization systems delivered similar biotransformation efficiency. Overall, the results suggest that the EUP pathway was functional and could support a whole cell biocatalytic reaction converting butanone to 2-butanol. HPLC analysis of metabolite concentration revealed that cells fed with ethanol also had the highest butanone uptake and utilization (figure 3b). This suggests a correlation between NADH regeneration and butanone consumption. Next, profile of ethanol utilization efficiency revealed a large residual amount of ethanol in the system after 2 days of incubation, with only 2-3 g/L of ethanol utilized (figure 3c). The data also suggests a possible fundamental constraint in ethanol utilization that could likely be associated with anaerobic biotransformation conditions. For resting cells, acetyl-CoA could accumulate as there is a lack of growth processes that siphon off the produced acetyl-CoA. But, experimental data suggests that acetate may be the final product of EUP operation in resting cells given its relatively high titer and progressive increase in concentration with incubation time (figure 3d). What likely transpires may be that acetyl-CoA from EUP was transformed to acetate through acetyl-phosphate. 

Efforts were also directed towards tuning parameters such as ethanol and butanone concentration to improve biotransformation efficiency. This arises because both the EUP pathway and cpsADH power reversible reactions. To improve NADH regeneration and product formation, ethanol and butanone concentration would need to be increased to push the equilibrium position forward towards product formation. In terms of ethanol provision, experiment results elucidated a positive correlation between ethanol concentration and biotransformation efficiency for resting cells (Supplementary figure S2a). This indicates that higher ethanol concentration pushes flux towards acetyl-CoA in EUP and results in higher regeneration of NADH. However, such positive correlation was not observed in growing cell biotransformation where 10 g/L ethanol exerted some cellular toxicity. On the other hand, high substrate loading is always desired in biotransformation reactions to improve product titer. In this area, data revealed a clear substrate toxicity effect from single phase biotransformation (Supplementary figure S2b). Specifically, higher butanone concentration resulted in a decline in biotransformation efficiency for resting cells precultivated in either LB or M9 + 10 g/L ethanol medium. Such toxicity effect could arise from the elevated butanone concentration experienced by the cells during biotransformation. 

Figure 4. Comparison of biotransformation efficiency of EUP and GDH in resting cells with either 10 g/L glucose or 10 g/L ethanol as co-substrates at 37 oC and 225 rpm under anaerobic conditions. A) EUP delivered higher biotransformation efficiency compared to GDH irrespective of the growth medium in which the resting cells were precultivated, B) Butanone utilization per unit OD showed the same trend as yield per unit OD across the different categories tested in resting cells precultivated in M9 + 10 g/L ethanol medium, which suggests that amount of NADH regenerated drives butanone utilization, C) Cells with EUP pathway utilized more ethanol compared to cells with endogenous ethanol utilization system (E. coli cps2), which indicates that heterologous EUP was expressed and was functional, D) More glucose was consumed by cells with GDH compared to cells with endogenous glucose utilization system (E. coli cps2). Inability to fully utilize glucose over 2 days meant that a fundamental limit may exist in glucose utilization under anaerobic conditions which precludes loading of more glucose into the biotransformation system to enable equimolar comparisons between the two substrates. Data for C and D were obtained from resting cells precultivated in M9 + 10 g/L ethanol medium. 

Prior experiments have demonstrated the utility of EUP in regenerating NADH in support of a ketone to alcohol biotransformation occurring in E. coli BL21 (DE3) whole cells. But, we do not yet know its relative efficacy in regenerating NADH and promoting biotransformation compared to other systems such as glucose dehydrogenase (GDH). Thus, work started in this project to clone GDH from Bacillus subtilis to serve as comparison for the EUP system. GDH gene was successfully cloned by PCR and inserted into the same vector as EUP under the control of the same autoinducible pthrC3 promoter to afford fair comparison between the two NADH regeneration systems. Similar to EUP, the plasmid encoding GDH was co-transformed with plasmid encoding cpsADH into E. coli BL21 (DE3) to constitute strain E. coli GDHcps1 for biotransformation.

In resting cells experiment with E. coli cps2 fed with either 10 g/L glucose or 10 g/L ethanol as controls, EUP pathway delivered higher biotransformation efficiency compared to GDH irrespective of whether LB or M9 + 10 g/L ethanol was used for precultivation (figure 4a). Such data corroborate theoretical reasonings that EUP would deliver higher NADH regeneration efficiency compared to GDH as EUP regenerates two NADH molecule per ethanol molecule compared to GDH regeneration of one NADH per glucose molecule. At the same time, both GDH and EUP delivered higher biotransformation efficiency compared to their respective endogenous glucose or ethanol utilization systems, which indicated that heterologous expression of GDH and EUP were successful and both cofactor regeneration systems were functional. Butanone utilization per unit OD also provided useful yardsticks for assessing the relative performance of GDH and EUP. Specifically, data revealed that butanone utilization was higher for cells with EUP compared to those with GDH (figure 4b). This suggests that NADH regeneration efficiency is intimately tied to butanone consumption, which higher NADH regeneration driving higher butanone consumption.

To compare the relative efficiency of two NADH regeneration systems require fair comparison of their substrate utilization. This then require equal amount of glucose or ethanol to be provided to the cells under the molar basis. But data from figure 4c and figure 4d concerning glucose and ethanol utilization imply that the above idea may not be possible in this system. Specifically, glucose could not be completely consumed over 2 days, which suggests a fundamental limit to glucose consumption may exist in the system. Such a situation then precludes the use of equimolar concentration of glucose and ethanol for determining the relative efficiency of GDH and EUP cofactor regeneration system. The data collected suggests that ethanol utilization with EUP may be a better NADH regeneration system compared to glucose utilization with GDH after considering substrate consumption by cells in a whole cell biocatalytic system. Overall, the data and analysis reported here points to the need to consider limitations in substrate uptake by cells during comparison of relative efficiency of different cofactor regeneration systems in whole cell biocatalysis systems. 

Figure 5. Comparison between the biotransformation efficiency achievable for resting and growing cells either precultivated or grown in M9 + 10 g/L ethanol medium. A) Growing cells delivered a higher biotransformation efficiency over resting cells for those fed with ethanol, B) Ethanol utilization per unit OD was also higher for growing cells than resting cells, bearing testament to the effect of driving force from cell growth that led to increased ethanol consumption and NADH regeneration, C) Acetate formation per unit OD was also higher for growing cells compared to resting cells, which confirms that growing cells drove greater flux from ethanol to acetyl-CoA and on to acetate through acetyl-phosphate, D) Cells could grow in M9 + 10 g/L ethanol medium during growing cell biotransformation, but growth was retarded probably due to toxicity of butanone. All experiments conducted in this series were performed under anaerobic conditions at 37 oC and 225 rpm. 

Growing cells have been used in many areas of metabolic engineering to drive flux down a designated metabolic pathway to deliver higher product yield. This approach relies heavily on engineering particular nodes or intermediates to be coupled to cell growth, which would subsequently drive flux to move towards the engineered nodes in the metabolic network. In this project, the EUP pathway ends at acetyl-CoA, which is a natural growth promoting metabolite; thus, cell growth should be able to draw flux from acetyl-CoA for building biomass, and hence, help move flux from ethanol to acetyl-CoA that helps regenerate more NADH in support of biotransformation. 

Experiment data verified theoretical predictions that growing cell should deliver a higher biotransformation efficiency compared to resting cells (figure 5a). But, what is of greater interest is the confirmation, from metabolite utilization and production data, that indeed, growing cells delivered a driving force to improve carbon flux from ethanol to acetyl-CoA and help improve NADH regeneration in support of biotransformation. To do this, both ethanol utilization and acetate formation was monitored by HPLC. In particular, ethanol utilization per unit OD revealed that growing cells helped improve ethanol consumption compared to resting cells (figure 5b). This result validates that growing cells could improve ethanol utilization by forcing flux to move down the EUP pathway. At the other end of the pathway, observations of increased acetate formation per unit OD in growing cells compared to resting cells again validated that cell growth drove flux from ethanol to acetyl-CoA which is converted to acetate through acetyl-phosphate (figure 5c). Part of the reason there was high acetate concentration in growing cells despite channelling of acetyl-CoA flux to cell growth in growing cell biotransformation could be the limited cell growth in M9 + 10 g/L ethanol medium (figure 5d). Such limited growth is opposite to observed good growth of E. coli ethcps2 in M9 + 10 g/L ethanol medium under anaerobic conditions without butanone input. This thus indicates that butanone exerted a toxicity effect on E. coli, especially with ethanol as a growth substrate. 

Figure 6. Effect of growth medium on biotransformation efficiency in resting and growing cells. A) Cells precultivated in M9 + 10 g/L ethanol medium delivered higher biotransformation efficiency compared to those precultivated in LB medium during resting cell biotransformation, B) Similarly, cells cultivated in M9 + 10 g/L ethanol delivered higher yield per unit OD compared to those cultivated in LB medium during growing cell biotransformation. All experiments were conducted under anaerobic conditions at 37 oC and 225 rpm.

Growth medium influences the gene expression pattern of cells, and this may have an impact on biotransformation efficiency such as that manifested by lower expression of NADH dependent enzymes that would compete for NADH originally slated for biotransformation. In the context of this work, the growth medium effect could be present in both resting cell and growing cell biotransformation. This last segment of the work aims to probe how two common growth media (LB and M9 + 10 g/L ethanol) in biocatalysis would influence biotransformation efficiency of butanone in resting and growing cells. Experimental results revealed that in resting cell biotransformation, cells precultivated in M9 + 10 g/L ethanol medium delivered higher biotransformation efficiency compared to those precultivated in LB medium (figure 6a). The effect was independent of whether glucose or ethanol was used as the co-substrate in resting cell biotransformation, and suggests that observed phenomenon cannot be solely attributed to “training effect” of cells precultivated in medium with ethanol supplementation. In growing cells biotransformation, cells grown in M9 + 10 g/L ethanol medium also delivered higher biotransformation efficiency compared to those grown in LB medium (figure 6b). Overall, growth medium effect studies indicated that M9 + 10 g/L ethanol medium may be better for improving butanone biotransformation efficiency through enhancing NADH regeneration. A possible reason that could account for the observation could be lower expression of NADH dependent enzymes in cells precultivated or cultivated in M9 + 10 g/L ethanol medium. This way, there would be less competition for regenerated NADH, and more of it could be used by cpsADH to drive butanone conversion into 2-butanol. 

Discussion

Cofactor regeneration is an established technology in biocatalysis, but the search remains for new sacrificial substrate and enzymes capable of delivering enhanced cofactor regeneration at a cheaper cost [29]. In addition, the trend has been moving towards pathway-based cofactor regeneration where the cofactors could be usefully tapped for balancing the redox environment in metabolic engineering applications [30]. With the search for new sacrificial substrates, there is also a recent trend in coupling novel synthetic pathway for substrate utilization with cofactor regeneration [31] [32]. This work espouses this concept where a two-gene EUP pathway channel flux from ethanol to acetyl-CoA in central carbon metabolism, while also producing NADH useful for cofactor regeneration in whole-cell biocatalysis. 

Experimental results in this study confirm that EUP could be readily integrated with cpsADH to constitute a whole-cell biocatalytic system able to convert ketone (acetophenone or butanone) to alcohol (1-phenylethanol or 2-butanol) in either two-phase or single-phase biotransformation systems. Irrespective of the main biotransformation product, conversion of ketone to alcohol is not 99% as documented by many studies in biocatalysis [33] [34] [35]. HPLC data of ethanol consumption suggests that inadequate uptake of ethanol by engineered E. coli cells could be the underlying constraint for relatively poor conversion and product yield. Most probably, such a constraint could arises from the toxicity effect of ethanol on cells [36] [37]. Work done in bioethanol production suggests that whether at the cell level or proteome level, ethanol exerts wide spectrum toxicity effect of cells causing physiological effects such as cell envelope stress and reduced cell growth [37]. Altogether, such toxicity effects and stresses could retard the uptake of ethanol, without which conversion and product yield would be poor.

Comparative assessment of EUP and glucose dehydrogenase (GDH) system in butanone biotransformation saw enhanced biotransformation efficiency from EUP compared to GDH in whole cells provided with equal mass concentration of glucose and ethanol. Inability of whole-cell system to fully utilize glucose nevertheless precluded a more comprehensive assessment of the two NADH regeneration systems at an equimolar basis in this project. However, glucose/GDH is by far the most often used NADH cofactor regeneration system due to low cost of glucose as well as the ease of utilizing glucose [38]. Thus, it is expected that EUP could only serve specialist applications in the foreseeable future. 

On the other hand, efforts in this project to address the equilibrium limited product profile from a reversible pathway saw success where higher ethanol concentration drove higher NADH regeneration and better biotransformation efficiency. Presence of reversible reactions in EUP is perhaps one critical bottleneck for allowing the pathway to deliver higher product yield. Equilibrium control of the pathway coupled with toxicity of ethanol meant that there is unlikely to be 100% consumption of ethanol that is necessary for improving conversion and product yield. Future effort should be directed to discovering irreversible reactions powered by enzymes from microbial species that could aid the construction of an enhanced EUP pathway.

But, the most prominent characteristic of the EUP pathway remains its ability to be tapped by cell growth processes to generate a driving force through the pathway that enhance NADH regeneration. Specifically, EUP ends in acetyl-CoA, which is a growth promoting metabolite in central carbon metabolism, and thus, allow growth processes to draw flux down the EUP pathway. Use of growth processes to deliver a driving force has delivered many success stories in metabolic engineering [39] [40], but the approach is less often used in biocatalysis. Data from this project supported the above theoretical prediction and clarified the pathway characteristics necessary for engendering growth-derived driving force for ethanol consumption and cofactor regeneration. 

Conclusion

This project demonstrated that a two-gene ethanol utilization pathway (EUP) is useful for regenerating NADH for a ketone to alcohol biotransformation in E. coli. Furthermore, EUP is shown to be more efficient in regenerating NADH compared to the gold standard, glucose dehydrogenase. Growing cells was shown to deliver a driving force to pull ethanol to acetyl-CoA, and thereby, help regenerate more NADH, and deliver higher alcohol yield. Finally, cultivation in M9 medium possibly reduces the expression of NADH requiring enzymes, thereby, helping to preserve the pool of NADH regenerated for supporting biocatalytic reaction, and delivering higher product yield. Overall, EUP could be used in supporting biocatalysis as well as rebalancing the intracellular redox environment in metabolic engineering applications. 

Conflicts of interest

The author declares no conflicts of interest.

Funding

The author thank the National University of Singapore for financial support.

References

Clearly Auctoresonline and particularly Psychology and Mental Health Care Journal is dedicated to improving health care services for individuals and populations. The editorial boards' ability to efficiently recognize and share the global importance of health literacy with a variety of stakeholders. Auctoresonline publishing platform can be used to facilitate of optimal client-based services and should be added to health care professionals' repertoire of evidence-based health care resources.

img

Virginia E. Koenig

Journal of Clinical Cardiology and Cardiovascular Intervention The submission and review process was adequate. However I think that the publication total value should have been enlightened in early fases. Thank you for all.

img

Delcio G Silva Junior

Journal of Women Health Care and Issues By the present mail, I want to say thank to you and tour colleagues for facilitating my published article. Specially thank you for the peer review process, support from the editorial office. I appreciate positively the quality of your journal.

img

Ziemlé Clément Méda

Journal of Clinical Research and Reports I would be very delighted to submit my testimonial regarding the reviewer board and the editorial office. The reviewer board were accurate and helpful regarding any modifications for my manuscript. And the editorial office were very helpful and supportive in contacting and monitoring with any update and offering help. It was my pleasure to contribute with your promising Journal and I am looking forward for more collaboration.

img

Mina Sherif Soliman Georgy

We would like to thank the Journal of Thoracic Disease and Cardiothoracic Surgery because of the services they provided us for our articles. The peer-review process was done in a very excellent time manner, and the opinions of the reviewers helped us to improve our manuscript further. The editorial office had an outstanding correspondence with us and guided us in many ways. During a hard time of the pandemic that is affecting every one of us tremendously, the editorial office helped us make everything easier for publishing scientific work. Hope for a more scientific relationship with your Journal.

img

Layla Shojaie

The peer-review process which consisted high quality queries on the paper. I did answer six reviewers’ questions and comments before the paper was accepted. The support from the editorial office is excellent.

img

Sing-yung Wu

Journal of Neuroscience and Neurological Surgery. I had the experience of publishing a research article recently. The whole process was simple from submission to publication. The reviewers made specific and valuable recommendations and corrections that improved the quality of my publication. I strongly recommend this Journal.

img

Orlando Villarreal

Dr. Katarzyna Byczkowska My testimonial covering: "The peer review process is quick and effective. The support from the editorial office is very professional and friendly. Quality of the Clinical Cardiology and Cardiovascular Interventions is scientific and publishes ground-breaking research on cardiology that is useful for other professionals in the field.

img

Katarzyna Byczkowska

Thank you most sincerely, with regard to the support you have given in relation to the reviewing process and the processing of my article entitled "Large Cell Neuroendocrine Carcinoma of The Prostate Gland: A Review and Update" for publication in your esteemed Journal, Journal of Cancer Research and Cellular Therapeutics". The editorial team has been very supportive.

img

Anthony Kodzo-Grey Venyo

Testimony of Journal of Clinical Otorhinolaryngology: work with your Reviews has been a educational and constructive experience. The editorial office were very helpful and supportive. It was a pleasure to contribute to your Journal.

img

Pedro Marques Gomes

Dr. Bernard Terkimbi Utoo, I am happy to publish my scientific work in Journal of Women Health Care and Issues (JWHCI). The manuscript submission was seamless and peer review process was top notch. I was amazed that 4 reviewers worked on the manuscript which made it a highly technical, standard and excellent quality paper. I appreciate the format and consideration for the APC as well as the speed of publication. It is my pleasure to continue with this scientific relationship with the esteem JWHCI.

img

Bernard Terkimbi Utoo

This is an acknowledgment for peer reviewers, editorial board of Journal of Clinical Research and Reports. They show a lot of consideration for us as publishers for our research article “Evaluation of the different factors associated with side effects of COVID-19 vaccination on medical students, Mutah university, Al-Karak, Jordan”, in a very professional and easy way. This journal is one of outstanding medical journal.

img

Prof Sherif W Mansour

Dear Hao Jiang, to Journal of Nutrition and Food Processing We greatly appreciate the efficient, professional and rapid processing of our paper by your team. If there is anything else we should do, please do not hesitate to let us know. On behalf of my co-authors, we would like to express our great appreciation to editor and reviewers.

img

Hao Jiang

As an author who has recently published in the journal "Brain and Neurological Disorders". I am delighted to provide a testimonial on the peer review process, editorial office support, and the overall quality of the journal. The peer review process at Brain and Neurological Disorders is rigorous and meticulous, ensuring that only high-quality, evidence-based research is published. The reviewers are experts in their fields, and their comments and suggestions were constructive and helped improve the quality of my manuscript. The review process was timely and efficient, with clear communication from the editorial office at each stage. The support from the editorial office was exceptional throughout the entire process. The editorial staff was responsive, professional, and always willing to help. They provided valuable guidance on formatting, structure, and ethical considerations, making the submission process seamless. Moreover, they kept me informed about the status of my manuscript and provided timely updates, which made the process less stressful. The journal Brain and Neurological Disorders is of the highest quality, with a strong focus on publishing cutting-edge research in the field of neurology. The articles published in this journal are well-researched, rigorously peer-reviewed, and written by experts in the field. The journal maintains high standards, ensuring that readers are provided with the most up-to-date and reliable information on brain and neurological disorders. In conclusion, I had a wonderful experience publishing in Brain and Neurological Disorders. The peer review process was thorough, the editorial office provided exceptional support, and the journal's quality is second to none. I would highly recommend this journal to any researcher working in the field of neurology and brain disorders.

img

Dr Shiming Tang

Dear Agrippa Hilda, Journal of Neuroscience and Neurological Surgery, Editorial Coordinator, I trust this message finds you well. I want to extend my appreciation for considering my article for publication in your esteemed journal. I am pleased to provide a testimonial regarding the peer review process and the support received from your editorial office. The peer review process for my paper was carried out in a highly professional and thorough manner. The feedback and comments provided by the authors were constructive and very useful in improving the quality of the manuscript. This rigorous assessment process undoubtedly contributes to the high standards maintained by your journal.

img

Raed Mualem

International Journal of Clinical Case Reports and Reviews. I strongly recommend to consider submitting your work to this high-quality journal. The support and availability of the Editorial staff is outstanding and the review process was both efficient and rigorous.

img

Andreas Filippaios

Thank you very much for publishing my Research Article titled “Comparing Treatment Outcome Of Allergic Rhinitis Patients After Using Fluticasone Nasal Spray And Nasal Douching" in the Journal of Clinical Otorhinolaryngology. As Medical Professionals we are immensely benefited from study of various informative Articles and Papers published in this high quality Journal. I look forward to enriching my knowledge by regular study of the Journal and contribute my future work in the field of ENT through the Journal for use by the medical fraternity. The support from the Editorial office was excellent and very prompt. I also welcome the comments received from the readers of my Research Article.

img

Dr Suramya Dhamija

Dear Erica Kelsey, Editorial Coordinator of Cancer Research and Cellular Therapeutics Our team is very satisfied with the processing of our paper by your journal. That was fast, efficient, rigorous, but without unnecessary complications. We appreciated the very short time between the submission of the paper and its publication on line on your site.

img

Bruno Chauffert

I am very glad to say that the peer review process is very successful and fast and support from the Editorial Office. Therefore, I would like to continue our scientific relationship for a long time. And I especially thank you for your kindly attention towards my article. Have a good day!

img

Baheci Selen

"We recently published an article entitled “Influence of beta-Cyclodextrins upon the Degradation of Carbofuran Derivatives under Alkaline Conditions" in the Journal of “Pesticides and Biofertilizers” to show that the cyclodextrins protect the carbamates increasing their half-life time in the presence of basic conditions This will be very helpful to understand carbofuran behaviour in the analytical, agro-environmental and food areas. We greatly appreciated the interaction with the editor and the editorial team; we were particularly well accompanied during the course of the revision process, since all various steps towards publication were short and without delay".

img

Jesus Simal-Gandara

I would like to express my gratitude towards you process of article review and submission. I found this to be very fair and expedient. Your follow up has been excellent. I have many publications in national and international journal and your process has been one of the best so far. Keep up the great work.

img

Douglas Miyazaki

We are grateful for this opportunity to provide a glowing recommendation to the Journal of Psychiatry and Psychotherapy. We found that the editorial team were very supportive, helpful, kept us abreast of timelines and over all very professional in nature. The peer review process was rigorous, efficient and constructive that really enhanced our article submission. The experience with this journal remains one of our best ever and we look forward to providing future submissions in the near future.

img

Dr Griffith

I am very pleased to serve as EBM of the journal, I hope many years of my experience in stem cells can help the journal from one way or another. As we know, stem cells hold great potential for regenerative medicine, which are mostly used to promote the repair response of diseased, dysfunctional or injured tissue using stem cells or their derivatives. I think Stem Cell Research and Therapeutics International is a great platform to publish and share the understanding towards the biology and translational or clinical application of stem cells.

img

Dr Tong Ming Liu

I would like to give my testimony in the support I have got by the peer review process and to support the editorial office where they were of asset to support young author like me to be encouraged to publish their work in your respected journal and globalize and share knowledge across the globe. I really give my great gratitude to your journal and the peer review including the editorial office.

img

Husain Taha Radhi

I am delighted to publish our manuscript entitled "A Perspective on Cocaine Induced Stroke - Its Mechanisms and Management" in the Journal of Neuroscience and Neurological Surgery. The peer review process, support from the editorial office, and quality of the journal are excellent. The manuscripts published are of high quality and of excellent scientific value. I recommend this journal very much to colleagues.

img

S Munshi

Dr.Tania Muñoz, My experience as researcher and author of a review article in The Journal Clinical Cardiology and Interventions has been very enriching and stimulating. The editorial team is excellent, performs its work with absolute responsibility and delivery. They are proactive, dynamic and receptive to all proposals. Supporting at all times the vast universe of authors who choose them as an option for publication. The team of review specialists, members of the editorial board, are brilliant professionals, with remarkable performance in medical research and scientific methodology. Together they form a frontline team that consolidates the JCCI as a magnificent option for the publication and review of high-level medical articles and broad collective interest. I am honored to be able to share my review article and open to receive all your comments.

img

Tania Munoz

“The peer review process of JPMHC is quick and effective. Authors are benefited by good and professional reviewers with huge experience in the field of psychology and mental health. The support from the editorial office is very professional. People to contact to are friendly and happy to help and assist any query authors might have. Quality of the Journal is scientific and publishes ground-breaking research on mental health that is useful for other professionals in the field”.

img

George Varvatsoulias

Dear editorial department: On behalf of our team, I hereby certify the reliability and superiority of the International Journal of Clinical Case Reports and Reviews in the peer review process, editorial support, and journal quality. Firstly, the peer review process of the International Journal of Clinical Case Reports and Reviews is rigorous, fair, transparent, fast, and of high quality. The editorial department invites experts from relevant fields as anonymous reviewers to review all submitted manuscripts. These experts have rich academic backgrounds and experience, and can accurately evaluate the academic quality, originality, and suitability of manuscripts. The editorial department is committed to ensuring the rigor of the peer review process, while also making every effort to ensure a fast review cycle to meet the needs of authors and the academic community. Secondly, the editorial team of the International Journal of Clinical Case Reports and Reviews is composed of a group of senior scholars and professionals with rich experience and professional knowledge in related fields. The editorial department is committed to assisting authors in improving their manuscripts, ensuring their academic accuracy, clarity, and completeness. Editors actively collaborate with authors, providing useful suggestions and feedback to promote the improvement and development of the manuscript. We believe that the support of the editorial department is one of the key factors in ensuring the quality of the journal. Finally, the International Journal of Clinical Case Reports and Reviews is renowned for its high- quality articles and strict academic standards. The editorial department is committed to publishing innovative and academically valuable research results to promote the development and progress of related fields. The International Journal of Clinical Case Reports and Reviews is reasonably priced and ensures excellent service and quality ratio, allowing authors to obtain high-level academic publishing opportunities in an affordable manner. I hereby solemnly declare that the International Journal of Clinical Case Reports and Reviews has a high level of credibility and superiority in terms of peer review process, editorial support, reasonable fees, and journal quality. Sincerely, Rui Tao.

img

Rui Tao

Clinical Cardiology and Cardiovascular Interventions I testity the covering of the peer review process, support from the editorial office, and quality of the journal.

img

Khurram Arshad